Food Establishment Inspection Report
Page 1  of ????????? 
Lake logo Lake County Health Department
and Community Health Center
500 West Winchester Road Suite 102
Libertyville, IL 60048
Establishment
 SPEEDWAY #7350 		License/Permit #
 008754
Street Address
5499 GRAND AVE
City/State
 GURNEE, IL 		ZIP Code
 60031
No. of Risk Factor/Intervention Violations 3
No. of Repeat Risk Factor/Intervention Violations 0
Date 08/14/2023
Time In 11:00 AM
Time Out 12:15 PM
Permit Holder/Person Interviewed/Person In Charge (PIC)
ZAC BUDDENHAGEN 		Risk Category
High
Purpose of Inspection   Routine

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
 Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
 Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized X  
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
 Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
 Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45 X Single-use/single-service articles: properly stored & used X  
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishment: SPEEDWAY #7350 License/Permit #: 008754 Date: 08/14/2023
Water Supply:   Community Non-Community Licensed Non-Community    Waste Water System:   Community On-Site IEPA System
Sanitizer: Temperature Logs in Use:
Location Method Sanitizer Type Concentration (PPM) Heat(F)
3-Compartment Sink Chemical Sanitizer Quaternary Ammonium 300 0.00
Wiping Cloth Bucket Chemical Sanitizer Quaternary Ammonium 300 0.00
CFPM Verification (name, expiration date, ID#):
       
Presentation Type: VISUAL Number Attended: 2
HACCP Discussed HACCP Principle Plan Onsite
3. Establish the Critical Limit for the CCP Discussed the HACCP principle of identifying critical control points such as hot holding at 135 degrees F or above and cold holding at 41 degrees F or below.

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
CHEESE/COLD WELL 37.00°F CHICKEN/DRAWER COOLER 38.00°F SOUR CREAM/ONE-DOOR UPRIGHT COOLER 38.00°F
CHEESE/REACH-IN COOLER 39.00°F CUT FRESH TOMATOES/REACH-IN COOLER 37.00°F CHEESE/REACH-IN COOLER 38.00°F
CORN DOG/REACH-IN COOLER 37.00°F PICO DE GALLO/SALAD BAR 37.00°F MILK/WALK-IN COOLER 40.00°F
CHEESE/WALK-IN COOLER 38.00°F CHICKEN/REACH-IN FREEZER -1.00°F ICE CREAM/TWO-DOOR UPRIGHT FREEZER -8.00°F
PORK/WALK-IN FREEZER -1.00°F CORN DOG/HOT BOX 156.00°F CHICKEN/ROLLER WARMER 158.00°F
HOT DOGS/ROLLER WARMER 158.00°F RICE/STEAM TABLE 171.00°F BEANS/STEAM TABLE 168.00°F
BEEF/STEAM TABLE 188.00°F CHEESE/RECEIVING 37.00°F    

OBSERVATIONS AND CORRECTIVE ACTIONS
P=Priority      PF=Priority Foundation      C=Core      R=Repeat
Item
Number 		P/PF/C/R Code Reference Violations cited in this report must be corrected within the time frames below.
16 P 4-501.114 (C) (C) A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at contact times shall meet the criteria Sanitizers, Criteria, shall be used in accordance with the EPA- registered label use instructions,?and shall be used as follows: (C) A quaternary ammonium compound solution shall: (1) Have a minimum temperature of 75 F, (2) Have a concentration and as indicated by the manufacturer's use directions included in the labeling, and (3) Be used only in water with 500 MG/L hardness or less or in water having a hardness no greater than specified by the EPA-registered label use instructions.
The level of chemical sanitizer in the three compartment sink is below the required concentration. The quaternary ammonium concentration adjusted to 300ppm.
The proper chemical sanitizing concentration was provided.
CORRECTED
5 PF 2-501.11 A FOOD ESTABLISHMENT shall have written procedures for EMPLOYEES to follow when responding to vomiting or diarrheal events that involve the discharge of vomitus or fecal matter onto surfaces in the FOOD ESTABLISHMENT. The procedures shall address the specific actions EMPLOYEES must take to minimize the spread of contamination and the exposure of EMPLOYEES, consumers, FOOD, and surfaces to vomitus or fecal matter.
Establishment does not have procedures for employees to follow when responding to discharging of vomitus or fecal matter.
Provide procedures to Clean-up of Vomiting and Diarrheal Events with in 10 days.
CORRECT BY: Aug 24, 2023
2 C 2-102.12 The person in charge shall be a certified food protection manager who has shown proficiency of required information through passing a test that is part of an accredited program (ANSI).
The PIC is not a certified food protection manager.
Register for an ANSI approved certified food protection manager course and successfully complete the course/examination within 60 days.
CORRECT BY: Oct 12, 2023
45 C 4-904.11 (A) (A) SINGLE-SERVICE and SINGLE-USE ARTICLES and cleaned and SANITIZED UTENSILS shall be handled, displayed, and dispensed so that contamination of FOOD- and lip-contact surfaces is prevented.
Clean disposable spoons are not protected from contamination at the pick-up area . Clean utensils and SSA shall be handled, displayed and dispensed so that food lip contact surfaces are protected from contamination. Spoons stored properly.
CORRECTED
49 C 4-601.11 (B) The FOOD-CONTACT SURFACES of cooking EQUIPMENT and pans shall be kept free of encrusted grease deposits and other soil accumulations.
The ice chute of the soda machine is soiled.
Complete detailed cleaning and sanitizing of the item(s) as required.
CORRECT BY NEXT ROUTINE INSPECTION
ZAC BUDDENHAGEN
Person In Charge (Signature)  		Olivera Lazarevic
Inspector 
Follow-up:  Yes   No   Follow-up Date:  08/24/2023